DB13(J)T 8483-2022 建筑起重机械使用年限管理规程

资源简介/截图：

资源简介/截图：
目叨 舀 根据河北省住房和城乡建设厅《河北 省工程建设标准和标准设 计复审结果的通知》 (冀建节科 〔2021)2号)的要求，河北省绿 色建材装备协会会同有关单位在原 《建筑起重机械报废规程》 DB13(J)73一2008基础上修编而成。在修编过程中，广泛征求了科 研单位，建筑起重机械制造、租赁、安装、使用和检验检测等单位 有关方面的意见，最后经审查定稿。 本规程共分7章，主要内容包括 :1.总则;2.术语;3.基本 规定;4.整机报废条件;5.使用年限规定;6.重要结构件报废; 7.报废整机及部 (构)件的处置。 此次修编的内容包括:原来划 分使用年限是以起重力矩来划 分，使用单位不能很直观的判断设备使用年限，现采用起重力矩和 最大起重量划分使用年限，则更加清晰明确。 本规程由河北省绿色建材装备协会负责具 体内容的解释，由河 北省绿色建筑推广与建设标准编制中心负责管理。 规程在执行过程中，请各单位注意总结经验、 积累资料，随时 将有关意见和建议反馈到河北省绿色建材装备协会 (地址:河北省 石家庄市新华区新华西路 539号，邮编:050000，电话: 03 11一57227665，邮箱:125696171@叹.com)，以供今后修订时参考。 本规程主编单位、参编单位、主要起草人和审查人员名单: 主 编 单 位 :河北省绿色建材装备协会 参 编 单 位 :河北建设集团股份有限公司 河北建工集团有限责任公司 中建七局第一建筑有限公司 亚泰重工股份有限公司 中宏检测认证集团有限公司 湖北江汉建筑工程机械有限公司 中国建筑第五工程局有限公司 三一重工股份有限公司 中联重科股份有限公司 主要起草人: 张晓利 路保腾 杜保兴 许 楠 姚志玉 郎志军 陈 刚 贾宜斌 李芒原 孙志斌 周建军 刘春辉 李 根 王金玉 胡 敏 郭群禄 王 义 辛 超 王春芳 杜建辉 王海滨 魏 建 杜建辉 王海龙 邢林静 李少辉 张 红 李 佳 解国春 张文明 李红娟 王亚楠 颜 晓 赵国勇 王运波 王少峰 刘 健 吴俊仙 于 震 审 查 人 员 : 古慧春 谷进宝 崔建立 郝春红 王 峰 赵英军 文朝辉 范良义 李雪亮 目 次 总则··························································································⋯⋯1 术语··························································································⋯⋯2 基本规定··················································································⋯⋯3 整机报废条件··········································································⋯⋯5 使用年限规定··········································································⋯⋯6 5.1 塔式起重机使用年限规定····················································⋯⋯6 5.2 施工升降机使用年限规定····················································⋯⋯6 重要结构件报废·······················································.⋯⋯7 若旧 n.1 . 塔式起重机重要结构件报废 ‘2 曰 自 施工升降机重要结构件报废 7 报废整机及部 (构)件的处置············································⋯⋯10 本规程用词说明··········································································⋯⋯H 引用标准名录··············································································⋯⋯12 附:条文说明··············································································⋯⋯13 ColteltS 1 General provisi0ns’··································································⋯⋯1 2 Te rl11s’························································································⋯⋯2 3 Basic requirements’·································································⋯⋯3 4 Conditionsforc0111P1etescrapPingofhoistingmachinery⋯⋯5 5 Service hfe ofcral1es’····························································⋯⋯ 6 51 Service hfe of tower cranes················································⋯⋯ 6 5.2 Service hfe of buikler’5 hoist············································⋯⋯ 6 6 Scrappingof eritca1strUctura1on1P0nents’·······················⋯⋯7 61 ScrapPing criteria for in1P0rtant structural con1P0nents of tower cranes··············································································⋯⋯ 7 62 ScrapPing criteria for critical structural co川Ponents of builder，5 hoist·················································································⋯⋯ 8 7 DisPosalofscrapPedmachinery andcomPonents············⋯⋯10 ExPfanation of wording in this sPeifcation’··························⋯⋯H List of quoted stand盯ds’····························································⋯⋯12 Addition: ExPfanation of Provisions········································⋯⋯13